Volume 7 Issue 3
Jun.  2022
Turn off MathJax
Article Contents
Article Navigation >  Green Energy&Environment  > 2022  >  7(3): 457-466
Jiajun Liu, Kui Wu, Zhengke Li, Wensong Li, Yuqing Ning, Weiyan Wang, Yunquan Yang. Preparation of bimetal Co-Ni supported on Mg-Al oxide for chemocatalytic upgrading of tailored fermentation products to energy intensive fuels. Green Energy&Environment, 2022, 7(3): 457-466. doi: 10.1016/j.gee.2020.10.011
Citation: Jiajun Liu, Kui Wu, Zhengke Li, Wensong Li, Yuqing Ning, Weiyan Wang, Yunquan Yang. Preparation of bimetal Co-Ni supported on Mg-Al oxide for chemocatalytic upgrading of tailored fermentation products to energy intensive fuels. Green Energy&Environment, 2022, 7(3): 457-466. doi: 10.1016/j.gee.2020.10.011
shu

Preparation of bimetal Co-Ni supported on Mg-Al oxide for chemocatalytic upgrading of tailored fermentation products to energy intensive fuels

doi: 10.1016/j.gee.2020.10.011

  • School of Chemical Engineering, Xiangtan University, Xiangtan, Hunan, 411105, China

Funds:

This research was supported by the National Natural Science Foundation of China (No. 21776236 and 21676225), Scientific Research Fund of Hunan Provincial Education Department (19A478), Natural Science Foundation of Hunan Province (2018JJ2384), Engineering Research Centre of Chemical Process Simulation and Optimization of Ministry of Education, and Students’ innovation and entrepreneurship training program of Hunan province.

  • Received date 09 July 2020, Accepted date 10 October 2020, RevRecd date 04 September 2020, Publish date 17 October 2020,
    Abstract
  • The great challenge in the aldol condensation of tailored fermentation products (acetone-butanol-ethanol, ABE) into energy intensive fuels is to develop a suitable catalyst with high activity and low-cost. In this study, Co, Ni, and Co-Ni supported on Mg-Al oxide catalysts were prepared and their pore diameters were enlarged via adding active carbon as a hard template into Mg-Al hydrotalcite. During the aldol condensation reaction, the catalyst activity was enhanced after enlarging the pore diameter and Co-Ni bimetal supported catalyst presented the highest activity, which was resulted from that the electron transfer between Co and Ni in Co-Ni alloy enhanced the dehydrogenation activity and large pore lowered the mass transfer resistance. After optimizing the reaction conditions, acetone conversion and the total selectivity of C5-C11 desired products in the aldol condensation of ABE reached up to 76% and 90%, respectively. The stability study showed that the activity was decreased with the increase of reaction number because of the oxidation of metallic Co and Ni, but this could be solved via a simple hydrogen reduction method.

     

    • FullText(HTML)
  • loading
    • References(52)
  • [1]
    S. Chu, A. Majumdar, Nature 488 (2012) 294-303.
    [2]
    N. Savage, Nature 474 (2011) S9-S11.
    [3]
    S. Atsumi, T. Hanai, J.C. Liao, Nature 451 (2008) 86-89.
    [4]
    M. Kaldstrom, M. Lindblad, K. Lamminpaa, S. Wallenius, S. Toppinen, Ind. Eng. Chem. Res. 56 (2017) 13356-13366.
    [5]
    H. Li, A. Riisager, S. Saravanamurugan, A. Pandey, R.S. Sangwan, S. Yang, R. Luque, ACS Catal. 8 (2018) 148-187.
    [6]
    N.M. Eagan, M.D. Kumbhalkar, J.S. Buchanan, J.A. Dumesic, G.W. Huber, Nat. Rev. Chem. 3 (2019) 223-249.
    [7]
    J.T. Kozlowski, R.J. Davis, ACS Catal. 3 (2013) 1588-1600.
    [8]
    Y. Wang, M. Peng, J. Zhang, Z. Zhang, J. An, S. Du, H. An, F. Fan, X. Liu, P. Zhai, D. Ma, F. Wang, Nat. Commun. 9 (2018) 5183.
    [9]
    M. Balakrishnan, E.R. Sacia, S. Sreekumar, G. Gunbas, A.A. Gokhale, C.D. Scown, F.D. Toste, A.T. Bell, Proceedings of the National Academy of Sciences 112 (2015) 7645-7649.
    [10]
    K. Taguchi, H. Nakagawa, T. Hirabayashi, S. Sakaguchi, Y. Ishii, J. Am. Chem. Soc. 126 (2004) 72-73.
    [11]
    M.S. Kwon, N. Kim, S.H. Seo, I.S. Park, R.K. Cheedrala, J. Park, Angew. Chem. Int. Ed. 44 (2005) 6913-6915.
    [12]
    P. Anbarasan, Z.C. Baer, S. Sreekumar, E. Gross, J.B. Binder, H.W. Blanch, D.S. Clark, F.D. Toste, Nature 491 (2012) 235-239.
    [13]
    G. Xu, Q. Li, J. Feng, Q. Liu, Z. Zhang, X. Wang, X. Zhang, X. Mu, ChemSusChem 7 (2014) 105-109.
    [14]
    H.T. Vo, S.M. Yeo, D. Dahnum, J. Jae, C.S. Hong, H. Lee, Chem. Eng. J. 313 (2017) 1486-1493.
    [15]
    B. Fridrich, M.C.A. Stuart, K. Barta, ACS Sustainable Chem. Eng. 6 (2018) 8468-8475.
    [16]
    S. Sreekumar, Z.C. Baer, A. Pazhamalai, G. Gunbas, A. Grippo, H.W. Blanch, D.S. Clark, F.D. Toste, Nat. Protoc. 10 (2015) 528-537.
    [17]
    L.-B. Sun, X.-Q. Liu, H.-C. Zhou, Chem. Soc. Rev. 44 (2015) 5092-5147.
    [18]
    X. Sheng, N. Li, G. Li, W. Wang, A. Wang, Y. Cong, X. Wang, T. Zhang, Green Chem. 18 (2016) 3707-3711.
    [19]
    Q. Zhu, C. Shen, J. Wang, T. Tan, ACS Sustainable Chem. Eng. 5 (2017) 8181-8191.
    [20]
    W. Shen, K. Komatsubara, T. Hagiyama, A. Yoshida, S. Naito, Chem. Commun. (2009) 6490-6492.
    [21]
    J. Blanco, A.L. Petre, M. Yates, M.P. Martin, S. Suarez, J.A. Martin, Adv. Mater. 18 (2006) 1162-1165.
    [22]
    Z. An, W. Wang, S. Dong, J. He, Catal. Today 319 (2019) 128-138.
    [23]
    L. Lu, Z. Rong, W. Du, S. Ma, S. Hu, ChemCatChem 1 (2009) 369-371.
    [24]
    W.-Z. Li, L. Kovarik, D. Mei, J. Liu, Y. Wang, C.H.F. Peden, Nat. Commun. 4 (2013) 2481.
    [25]
    N. Blanch-Raga, A.E. Palomares, J. Martinez-Triguero, M. Puche, G. Fetter, P. Bosch, Appl. Catal. B:Environ. 160-161 (2014) 129-134.
    [26]
    H. Chen, J. Zhao, S. Li, J. Xu, J. Shen, Chin. J. Catal. 36 (2015) 380-388.
    [27]
    L. He, H. Berntsen, E. Ochoa-Fernandez, J.C. Walmsley, E.A. Blekkan, D. Chen, Top. Catal. 52 (2009) 206-217.
    [28]
    Z. Wang, C. Wang, S. Chen, Y. Liu, Int. J. Hydrogen Energy 39 (2014) 5644-5652.
    [29]
    J. Pang, M. Zheng, L. He, L. Li, X. Pan, A. Wang, X. Wang, T. Zhang, J. Catal. 344 (2016) 184-193.
    [30]
    C. Rudolf, B. Dragoi, A. Ungureanu, A. Chirieac, S. Royer, A. Nastro, E. Dumitriu, Catal. Sci. Technol. 4 (2014) 179-189.
    [31]
    L. Zhang, X. Chen, Y. Chen, Z. Peng, C. Liang, Catal. Sci. Technol. 9 (2019) 1108-1116.
    [32]
    H. Li, H. Li, J. Zhang, W. Dai, M. Qiao, J. Catal. 246 (2007) 301-307.
    [33]
    J. Fang, X. Chen, B. Liu, S. Yan, M. Qiao, H. Li, H. He, K. Fan, J. Catal. 229 (2005) 97-104.
    [34]
    X. Feng, H. Wang, X. Bo, L. Guo, ACS Appl. Mater. Interfaces 11 (2019) 8018-8024.
    [35]
    C. Huang, H. Li, J. Yang, C. Wang, F. Hu, X. Wang, Z.-H. Lu, G. Feng, R. Zhang, Appl. Surf. Sci. 478 (2019) 708-716.
    [36]
    H. Wu, H. Liu, W. Yang, D. He, Catal. Sci. Technol. 6 (2016) 5631-5646.
    [37]
    S. Ribet, D. Tichit, B. Coq, B. Ducourant, F. Morato, J. Solid State Chem. 142 (1999) 382-392.
    [38]
    Q. Tang, Q. Zhang, P. Wang, Y. Wang, H. Wan, Chem. Mater. 16 (2004) 1967-1976.
    [39]
    I. Luisetto, S. Tuti, E. Di Bartolomeo, Int. J. Hydrogen Energy 37 (2012) 15992-15999.
    [40]
    B.M. Xaba, J.P.R. De Villiers, Ind. Eng. Chem. Res. 55 (2016) 9397-9407.
    [41]
    X. Zhang, J. Long, W. Kong, Q. Zhang, L. Chen, T. Wang, L. Ma, Y. Li, Energy Fuels 28 (2014) 2562-2570.
    [42]
    X. Liao, R. Gerdts, S.F. Parker, L. Chi, Y. Zhao, M. Hill, J. Guo, M.O. Jones, Z. Jiang, PCCP 18 (2016) 17311-17319.
    [43]
    W.-C. Li, A.-H. Lu, C. Weidenthaler, F. Schuth, Chem. Mater. 16 (2004) 5676-5681.
    [44]
    L. Bromberg, X. Su, T.A. Hatton, Chem. Mater. 25 (2013) 1636-1642.
    [45]
    H. Oh, Y.I. Lee, G. Lee, K. Min, J.S. Yi, J. Power Sources 345 (2017) 67-77.
    [46]
    G. Ye, H. Wang, X. Zhou, F.J. Keil, M.-O. Coppens, W. Yuan, AlChE J. 65 (2019) e16687.
    [47]
    E. Ruckenstein, H.Y. Wang, J. Catal. 205 (2002) 289-293.
    [48]
    Z. Liu, P. Lustemberg, R.A. Gutierrez, J.J. Carey, R.M. Palomino, M. Vorokhta, D.C. Grinter, P.J. Ramirez, V. Matolin, M. Nolan, M.V. Ganduglia-Pirovano, S.D. Senanayake, J.A. Rodriguez, Angew. Chem. Int. Ed. 56 (2017) 13041-13046.
    [49]
    S. Sreekumar, Z.C. Baer, E. Gross, S. Padmanaban, K. Goulas, G. Gunbas, S. Alayoglu, H.W. Blanch, D.S. Clark, F.D. Toste, ChemSusChem 7 (2014) 2445-2448.
    [50]
    K.A. Goulas, S. Sreekumar, Y. Song, P. Kharidehal, G. Gunbas, P.J. Dietrich, G.R. Johnson, Y.C. Wang, A.M. Grippo, L.C. Grabow, A.A. Gokhale, F.D. Toste, J. Am. Chem. Soc. 138 (2016) 6805-6812.
    [51]
    K.A. Goulas, G. Gunbas, P.J. Dietrich, S. Sreekumar, A. Grippo, J.P. Chen, A.A. Gokhale, F.D. Toste, ChemCatChem 9 (2017) 677-684.
    [52]
    H. Petitjean, K. Tarasov, F. Delbecq, P. Sautet, J.M. Krafft, P. Bazin, M.C. Paganini, E. Giamello, M. Che, H. Lauron-Pernot, G. Costentin, J. Phys. Chem. C 114 (2010) 3008-3016
    • Relative Articles
    • Supplements(0)
    • Cited By
  • 加载中

Catalog

    通讯作者: 陈斌, bchen63@163.com
    • 1. 

      沈阳化工大学材料科学与工程学院 沈阳 110142

    1. 本站搜索
    2. 百度学术搜索
    3. 万方数据库搜索
    4. CNKI搜索
    Get Citation
    PDF
    XML

    Article Metrics

    Article views (192) PDF downloads(14) Cited by()
    Proportional views

    Publish With GEE

    Contact

    • Email：gee@ipe.ac.cn
    • Tel：010-82627075
    • Address：North 2nd street, Zhongguancun, Haidian District, Beijing, China

    Links

    京ICP备10002620号-1京公网安备 11010802039050号

    Supported by: Beijing Renhe Information Technology Co. Ltd    

    /

    DownLoad:  Full-Size Img  PowerPoint
    Return
    Return